- Price per m²
- £78–£138
- Typical life
- 30–60 years
- Manufacturer guarantees
- 15-year material, up to 25-year system guarantees
- 30 m² roof
- £3,200–£5,750
Vale of Glamorgan at a glance
- Largest towns
- Barry, Penarth, Llantwit Major, Dinas Powys
- Postcode areas
- CF
- Building control
- Vale of Glamorgan Council
- Neighbouring areas
- Cardiff · Caerphilly · Bridgend · Rhondda Cynon Taf
- Guide price region
- Wales (−8% on West Midlands rates)
How much does mastic asphalt roofing cost in Vale of Glamorgan?
Guide prices including VAT at Wales rates. The fixed price comes after a free survey for new and replacement roofs.
| Job | Guide price inc VAT |
|---|---|
| Mastic asphalt roof (30 m²), scaffold | £3,200–£5,750 |
| Localised patch repair | £140–£460 |
| Single garage (18 m²), EPDM rubber | £1,450–£2,600 |
| Extension (20 m²), EPDM, new deck + insulation | £2,600–£4,500 |
Which flat roofs are common in Vale of Glamorgan?
Flat roofs in Vale of Glamorgan sit on 1930s semis with flat-roofed garages and kitchen extensions, low-rise post-war blocks of flats and newer estates where the first extension roofs are now being replaced. Wales averages roughly 1,460 mm of rain a year, among the wettest in Britain, so we design for steady run-off: proper falls, clear outlets and upstands well above the finished roof. Approximate 1991–2020 regional averages based on Met Office data.
Building regulations in Wales
Welsh guidance is that most re-roofing needs building control approval, so it's worth checking whenever more than a quarter of a roof is replaced or repaired. Renovated roofs are upgraded to around 0.16 W/m²K where feasible, and new extension roofs are built to 0.13 W/m²K under the Welsh Approved Document L. In Vale of Glamorgan the application goes to Vale of Glamorgan Council. More on the rules.
Should an old asphalt roof be repaired, overlaid or replaced, especially on a heritage building?
If the asphalt is sound apart from local cracks or blisters, repair it; if it is crazed and tired but dry and well bonded, consider an overlay; if it is leaking widely, sitting on a wet or failing deck, or full of trapped moisture, replace it. A survey, sometimes with a leak trace, tells you which applies.
- Repairs: blisters are cut out, cracks opened up and fresh asphalt worked in by a specialist, so the repair fuses with the existing roof.
- Overlay: a compatible system, often a reinforced liquid membrane, is bonded over the old asphalt after cleaning and priming. This keeps the old asphalt as a solid base and avoids heavy strip-out.
- Replacement: the old asphalt is broken out and the roof rebuilt, either in new asphalt or in another system the structure can carry, with insulation where required.
On heritage and older buildings, matching the original material and detailing often matters as much as waterproofing. New asphalt skirtings and aprons can follow the existing lines, and any change of material on a listed building should be agreed with the conservation officer before work starts.
Asphalt work is a specialist trade. It needs mixers or boilers on site, trained asphalters and strict hot-works control, so we plan these jobs around access, the building's occupants and the weather.
Is mastic asphalt still a good choice, or should I switch systems?
Mastic asphalt is still a good choice on concrete roofs, heritage and older buildings, and roofs that carry heavy foot traffic or plant. On lightweight timber roofs, garages and most modern extensions, another system is usually more practical.
Benefits: very long typical life; jointless and fully bonded; takes foot traffic well, especially with a paving finish; matches the original roof on many older buildings; local repairs blend into the existing surface.
Drawbacks: heavy, so the structure must be able to carry it; higher cost; needs specialist labour and hot works with molten material; can crack in cold if not well maintained, and softens in strong sun without a reflective finish.
If the structure is lightweight or the budget tight, torch-on felt or EPDM are common replacements. A compatible liquid-applied system can sometimes be laid over sound asphalt. On larger roofs, single-ply may be considered, and GRP suits smaller roofs needing a hard finish. Our repair or replace guide helps with the decision.
Which towns in Vale of Glamorgan do we cover?
Mastic asphalt roofing in Vale of Glamorgan: questions
Which towns in Vale of Glamorgan do you cover?
All of Vale of Glamorgan. The main towns have their own pages below, and if yours isn't listed we still cover it: send your postcode and we'll confirm.
How much does mastic asphalt roofing cost in Vale of Glamorgan?
£3,200–£5,750 for a 30 m² mastic asphalt roof including scaffold, at Wales guide rates including VAT. The fixed price comes after a free survey for new and replacement roofs.
Which postcode areas do you cover in Vale of Glamorgan?
All of Vale of Glamorgan, including the CF postcode areas. Send your full postcode and we'll confirm.
Can you put felt or rubber over an asphalt roof?
Sometimes, if the asphalt is dry, well bonded and sound, using a compatible system and primer. Liquid membranes are a common choice because they bond well to cleaned asphalt.
Why are mastic asphalt roofs painted silver or white?
The reflective coating keeps the asphalt cooler in sun, reducing softening and slowing the surface ageing that leads to crazing. It usually needs renewing every few years as part of maintenance.
Is mastic asphalt the same as tarmac?
No. Both contain bitumen, but mastic asphalt is a dense, voidless mix with fine limestone aggregate, made to be fully waterproof, while road surfacing is a different material.
Everything about mastic asphalt roofing → · All flat roofing in Vale of Glamorgan →