- Guide price
- £3,100–£5,350
- Survey
- Free for new and replacement roofs
- Quote
- Fixed, in writing
- Coverage
- England, Wales, Scotland, NI
West Sussex at a glance
- Largest towns
- Crawley, Worthing, Bognor Regis, Littlehampton
- Postcode areas
- BN, PO, RH
- Building control
- Crawley Borough Council, Worthing Borough Council, Arun District Council and 4 other councils
- Neighbouring areas
- East Sussex · Surrey · Hampshire · London
- Guide price region
- South East (+10% on West Midlands rates)
How much does a warm roof upgrade cost in West Sussex?
Guide prices including VAT at South East rates. The fixed price comes after a free survey for new and replacement roofs.
| Job | Guide price inc VAT |
|---|---|
| Extension (20 m²), EPDM, new deck + insulation | £3,100–£5,350 |
| Extension (20 m²), EPDM with sedum green roof | £4,850–£8,900 |
Which flat roofs are common in West Sussex?
Flat roofs in West Sussex sit on low-rise post-war blocks of flats, bungalows with flat-roofed side extensions and dormers and shops with flat-roofed rear stores below flats. Much of the South East sits in the drier Thames catchment at roughly 730 mm of rain a year, so the usual failures are at joints, upstands and outlets rather than from sheer volume of rain. Approximate 1991–2020 regional averages based on Met Office data.
Building regulations in England
Replacing more than half of a roof over a heated room usually counts as renovating a thermal element, so it is insulated to current standards and notified to building control. Renovated roofs over heated rooms are insulated to around 0.16 W/m²K where that's feasible, and new extension roofs are built to 0.15 W/m²K. In West Sussex the application goes to Crawley Borough Council, Worthing Borough Council, Arun District Council and 4 other councils. More on the rules.
Can a cold flat roof be converted to a warm roof?
Yes, and it is the usual approach when an older cold roof is re-covered. The old covering is stripped, the deck is checked and replaced where needed, and the vapour control layer, insulation and new waterproofing go on top.
The existing insulation between the joists is assessed at the same time. Leaving it in place can create a cold, unventilated gap that traps moisture, so it is often removed or the build-up is designed so that most of the insulation sits above the deck. We decide this case by case once we can see inside the roof. If the covering is still sound and you are only patching it, the upgrade isn't usually required, and our repair or replace guide explains how to decide between the two.
How long does a warm roof last?
The insulation in a warm roof should last for the life of the waterproofing above it, as long as it stays dry. Rigid PIR boards don't settle or slump in the way some loose insulation can.
The waterproofing is what sets the timescale. EPDM is typically quoted at 25 to 50 years, GRP at 20 to 40 years and modern torch-on felt at 15 to 25 years with good specification and care. A warm build-up also helps the deck, because keeping it warm and dry lowers the risk of condensation rot. If the waterproofing fails and water gets into the insulation, the wet boards should be replaced, so leaks need prompt attention. The lifespan guide compares the systems.
Which towns in West Sussex do we cover?
- Crawley
- Worthing
- Bognor Regis
- Littlehampton
- Horsham
- Haywards Heath
- Chichester
- Burgess Hill
- East Grinstead
- Shoreham-by-Sea
- Lancing
Warm roof insulation upgrades in West Sussex: questions
Which towns in West Sussex do you cover?
All of West Sussex. The main towns have their own pages below, and if yours isn't listed we still cover it: send your postcode and we'll confirm.
How much does a warm roof upgrade cost in West Sussex?
£3,100–£5,350 for a 20 m² extension roof in EPDM with a new deck and insulation, at South East guide rates including VAT. The fixed price comes after a free survey for new and replacement roofs.
Which postcode areas do you cover in West Sussex?
All of West Sussex, including the BN, PO, RH postcode areas. Send your full postcode and we'll confirm.
Will a warm roof make my room warmer?
Usually, yes. A room under a poorly insulated flat roof loses less heat once the roof is upgraded and tends to feel more even in temperature. How much difference you notice depends on how the roof was built before.
Can you insulate a flat roof from inside instead?
It is possible, but insulating between or under the joists creates a cold roof, which needs ventilation and carries a higher condensation risk. When the roof is being re-covered anyway, a warm roof from above is usually the better option.
Is there VAT relief on flat roof insulation?
Don't count on it. Insulation fitted as part of a roof replacement is usually treated as part of a single standard-rated job. Check your own case with HMRC guidance or an adviser.
Everything about warm roof insulation upgrades → · All flat roofing in West Sussex →